Dynamic characteristic study on bellows combination based on experimental design method

DING Zhongkai; ZHANG Guoqiang; WANG Liang; GU Yu; SHAO Zhiqiang

doi:10.13873/J.1000-9787(2020)07-0058-04

Chinese

您当前的位置：

首页 >

文章列表页 >

Dynamic characteristic study on bellows combination based on experimental design method

更新时间：2025-09-11

- Dynamic characteristic study on bellows combination based on experimental design method
- Vol. 39, Issue 7, Pages: 58-61(2020)
- 作者机构：
  
  1. 中国电子科技集团公司第四十九研究所
  2. 陆装驻西安地区航空军事代表室
  3. 中国电子科技集团有限公司
  4. 空装驻哈尔滨地区第一军事代表室
- 作者简介：
- 基金信息：
- DOI：10.13873/J.1000-9787(2020)07-0058-04
  CLC： V23
- Published：2020
- 稿件说明：
移动端阅览
[1]丁钟凯,张国强,王亮,谷雨,邵志强.基于试验设计法的波纹管组件动态特性研究[J].传感器与微系统,2020,39(07):58-61.

DING Zhongkai, ZHANG Guoqiang, WANG Liang, et al. Dynamic characteristic study on bellows combination based on experimental design method[J]. 2020, 39(7): 58-61.
[1]丁钟凯,张国强,王亮,谷雨,邵志强.基于试验设计法的波纹管组件动态特性研究[J].传感器与微系统,2020,39(07):58-61. DOI： 10.13873/J.1000-9787(2020)07-0058-04.

DING Zhongkai, ZHANG Guoqiang, WANG Liang, et al. Dynamic characteristic study on bellows combination based on experimental design method[J]. 2020, 39(7): 58-61. DOI： 10.13873/J.1000-9787(2020)07-0058-04.

摘要

通过建立波纹管组件力学模型

确定影响波纹管组件固有频率的结构因素;基于响应面法思想

利用试验设计的方法

以波纹管组件固有频率为指标

各结构参数为因素

设计二次回归中心旋转组合试验;通过ABAQUS6. 10软件建立各组试验结构参数组合下的分析模型

并提取固有频率

最终确定使固有频率维持在较高水平的结构参数组合区间。通过对优化后参数进行验证性试验

表明优化后区间随机结构参数组合下波纹管组件固有频率能够达到1500 Hz以上

具有很好的抗外界振动干扰能力

不易引起谐振。

Abstract

Through building mechanical model for bellows combination to ensure the structural factors which impact the natural frequency of bellows combination. Based on response surface thought

use experimental design methods

use the natural frequency of the bellows combination as index and each structural parameter as factor

design quadratic regression orthogonal rotation combination experiment. Each group of test structural parameters combinations analysis model can be founded by using ABAQUS 6. 10 software and extract the natural frequency.Finally

ensure the structure parameter combinations interval which makes the natural frequency maintain at a higher level. Through confirmatory test on the optimized parameters

it shows that the natural frequency of the bellows combination can reach above 1500 Hz after optimizing the interval random structure parameters combinations

it has very good interference ability

and it can not easy to cause resonance.

关键词

Keywords

references

加速度传感器壳体结构参数优化 [J]. 褚雷阳,于德润,刘宝伟,丁钟凯,符兴宇. 传感器与微系统 . 2014(12)

基于响应面模型的结构疲劳寿命优化方法 [J]. 薛彩军,谭伟,徐奋进,戴建华. 南京理工大学学报 . 2011(06)

基于正交试验设计的客车车身结构优化研究 [J]. 崔玲,高云凯. 制造业自动化 . 2010(12)

基于正交试验设计的多指标优化方法研究 [J]. 魏效玲,薛冰军,赵强. 河北工程大学学报(自然科学版) . 2010(03)

MEMS高g加速度传感器固有频率的优化及验证 [J]. 李平,石云波,朱正强,杜康,刘俊. 传感技术学报 . 2010(03)

动力装置压力开关的研制 [J]. 梁峭,孙海玮,刘宏伟,刘波. 仪表技术与传感器 . 2008(12)

金属波纹管的动态特性分析与振动试验研究 [J]. 熊永华,杜发荣,钟玉平. 中国机械工程 . 2008(10)

压力开关的过载与限位保护研究 [J]. 王金文. 传感器与微系统 . 2007(09)

简化有限元方法的波纹管模态分析 [J]. 刘文川,张锡文,何枫. 应用力学学报 . 2007(02)

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Structure optimization and simulation analysis of high-range acceleration sensor

Study on identification of modal parameters of piezoelectric thrust measuring device

Effect on drive micro beam width error on performance of micro gyroscope

Design and experimental study of novel bi-directional piezoelectric energy harvesting device

Recognition of sEMG hand actions based on artificial fish swarm algorithm optimized SVM

Related Author

GUO Tao

HAN Wenman

REN Zong-jin

XU Hong

ZHANG Jun

HAO Shu-ying

LI Hui-jie

QI Cheng-kun

Related Institution

Micron Nanotechnology Research Center of North University of China

School of Mechanical Engineering,Dalian University of Technology

Tianjin Key Laboratory of Design and Intelligent Control of Advanced Mechatronical System

School of Mechanical Engineering,Tianjin University of Technology

State Key Laboratory of Structural Analysis for Industrial Equipment,Dalian University of Technology

⁰